Solar Force Piston Pump 3020-115VAC

Home Store Learn

1.800.810.9939

Site Map

View Cart

Check Out

Support

Store

Solar Force Piston Pump 3020-115VAC
Item Code : 282
Our Price : $ 1,399.00
List Price: ~~$ 1,653.75~~
You Save: $ 254.75 (15.40 %)

Solar Force Piston Pump 3020-115VAC

Solar Force Piston Pump draws water from a shallow well, spring, pond, river or tank. It can push water uphill and over long distances for home, village, irrigation or livestock uses. It can use power directly from a photovoltaic array, or from storage batteries, to fill a storage tank or to pressurize water.

Ultra-Efficient: Uses less power than any other pump in its range

Economical: Reduces power system cost by 25-75% compared to centrifugal or AC pumps

Solar-Direct Application: Starts pumping in low light conditions

Pressurizing Application: DC version is most efficient. AC version uses a low-surge permanent magnet motor that greatly reduces starting surge, inverter size, and wire size requirements (when compared to conventional AC pumps).

Rugged and Reliable: Proven design with a 20–year life expectancy. Simple to maintain with common tools (5-10 yr. maintenance interval)

Good Tolerance for dirt and dry run

Mechanical Drive: allows engine or hand-lever backup.

Illustrated Instruction Manual: makes it easy for anyone to install and service, with no previous experience.

Construction

Cast iron body
Brass cylinder and valve seats
Leather cup piston seals
Neoprene valve seals
Oil-bath crankcase
Gear (timing) belt drive on PV models
Standard V-belt on B models
Pressure relief valve
Permanent Magnet DC Motor
Surge tank included (not in photo)

Suction Capacity

25 vertical feet (7.6 m) at sea level. Subtract 1 foot for every 1000 ft. elevation (1 m for every 1,000 m). Suction capacity may be further limited by intake pipe friction. Intake piping should be minimum 1” (3010, 3020 models) or minimum 1 1/4” (3040). For best reliability, place the pump as close to the water source as possible.

System Requirements

Solar-Direct Systems: Chart indicates power (w) required at the pump. The rated power of the PV array must exceed this number by 20 % or more. A pump controller (linear current booster) is required for the pump to start and run in varying light conditions. A solar tracker may be used to increase daily yield (40-55 % in summer).
Pressurizing Systems: battery power system, pressure switch, and pressure tank of minimum 60 gallon (230 l) size (captive-air tank, available locally)

Voltages Available:

12, 24, 48 VDC, Note: PV-Direct full working voltage is typically 20% higher than nominal (example: 29 Volts for a 24V system)
115V or 230V AC, 50-60Hz

Fittings

Intake: 1 1/4” female pipe thread
Outlet: 1” female pipe thread

Dimensions

22 x 13 x 16” high (56 x 33 x 41 cm)
With Surge Tank (not shown in photo)
Total height 26” (60 cm)
Weight, max. 80 lbs (36 kg)
Shipped in 2 or 3 boxes

Warranty: 2 years against defects in materials and workmanship

Products

Newsletter

Rebates